Results 1 to 4 of 4

Thread: bev air freezer

  1. #1
    Join Date
    Aug 2005
    Location
    iowa
    Posts
    1,649

    bev air freezer

    hey guys i got a question on a bev air freezer.


    m# kf12-1as

    the s# has been scrubbed off but i do know that this thing is less than 8 yrs old.

    the problem i am haveing is it freezes up about once a week.

    the timeclock is new and set correctly. 30 minutes every 6 hrs.

    the gasket is in good shape and is not tore. also the door closure works properly and will even pull the door closed if i only open it an inch or two.

    the charge is correct and the condensor is clean.

    the klixons both appear good and do function correctly. when i turn it into defrost it will always clean the coil completely before terminating defrost. also the fan stays off about 4 minutes out of defrost. also this unit has a door switch that shuts the evap fan off when the door is opened and this works correctly.

    the only other thing i can tell you is that the tstat was pegged at 9 and when i talked to bev air tech support they said if the tstat was set higher than 5 it will frost the coil.

    other than that this is a fry side freezer at an arbys. it has worked great until now. they always close the door immediately after getting their product. they have virtually zero turnover and have had the same manager for 20 yrs. man this place is run tight. i just cant figure out what i am missing.

    anybody got any ideas?

    thanks in advance.

    jeep

  2. #2
    Join Date
    Sep 2007
    Location
    NH
    Posts
    1,193
    Is the drain working and the drain heater working??

  3. #3
    Join Date
    Aug 2007
    Location
    Winter Haven, FL
    Posts
    4,380
    Go to the roof and check the a/c

  4. #4
    Join Date
    Aug 2005
    Location
    iowa
    Posts
    1,649
    drain heater is working.

    in response to the ac comment. it is 76 in the kitchen i didnt think to check the RH but i will tomorrow. i bet you are right.

    jeep

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
Comfortech Show Promo Image

Related Forums

Plumbing Talks | Contractor Magazine
Forums | Electrical Construction & Maintenance (EC&M) Magazine
Comfortech365 Virtual Event